Sport Planes (Formerly I/C & Gas Conversion) Discuss I/C or Gas Conversions, Aerobatic Planes and Sport Aircraft

Electrified Goldberg Cub

Old 05-24-2016, 09:03 PM
  #1  
Wrenchbody
Fullscale JetMech
Thread Starter
 
Wrenchbody's Avatar
 
Join Date: May 2016
Location: Baja Arizona
Posts: 4
Default Electrified Goldberg Cub

Kit built 23 year old Goldberg Anniversary Cub brought back into flying condition. The original build on this airframe included wing beef up mods in the center section allowing it to fly without wing struts and pull many Gs with no risk of failure. Old nitro burner K&B .61 was removed and clean electric conversion performed. Installed Exceed RC Monster Power .46 brushless outrunner with 5S lipo battery turning a 13 x 6.5E APC. All up weight with 3600 mAh pack comes in at 8 lbs. Metallic Plum Monokote with metallic green and chrome striping. Battle Troll for scale pilot effect. (Insult to Trolls everywhere)! New windshield from Fiberglass Specialties installed. Converted the original custom balsa cowling from gas to electric and recovered. Calculated 6 lbs. static thrust with this prop and almost 7 lbs. thrust with 13x8E here at 2600' elevation. Construction of the motor mount conversion as follows: #10 steel screws with nylon locking nuts. Stainless washers stacked with aluminum spacer tubing. Can change washer stacking to adjust the thrust angle of the prop. The mount ended up very rigid, even more than expected. No problem with a little extra weight in front and needed to move the motor 3 inches out from the firewall for weight and balance purposes. Have the heavy 3600 5S lipo as close to the firewall as possible in the cabin as well. 80A ESC handles an average 40A motor draw at full power with BEC supplying the receiver power. Used a 13x6.5E APC prop which should be drawing close to 35A given the average altitude and temps here in S. AZ. Have a 13x8E to install if needed which will push the amperage a little over 40 and add a lot of total thrust. It was at least 15 years since my last flight and more than that for the Cub, but still a pretty comfortable test flight. Very little initial trim needed for level flight at about half power lever angle. Was a "calm" wind day but still had unpredictable gusts to about 5-7 knots. Did several passes with touch and goes and 2 full stops. The last one with a quartering tailwind gust that left me stalled a little sooner than predicted. Resulted in a little wingtip rash on the RH side. Flying rouge off of a deserted dead end blacktop road, that tarmac was pretty unforgiving on the Monokote. Wingtips beefed up and protected with some 3M propeller erosion tape. Ready for some more flying, and the next conversion project.
Attached Images
File Type: jpg
RCaircraft 014sm.jpg (516.9 KB, 739 views)
File Type: jpg
RCaircraft 012sm.jpg (627.4 KB, 639 views)
File Type: jpg
RCaircraft 043sm.jpg (321.3 KB, 679 views)
File Type: jpg
RCaircraft 047sm.jpg (435.9 KB, 733 views)
File Type: jpg
RCaircraft 038sm.jpg (432.0 KB, 688 views)
File Type: jpg
RCaircraft 042sm.jpg (447.0 KB, 744 views)
File Type: jpg
RCaircraft 091sm.jpg (567.4 KB, 687 views)
File Type: jpg
RCaircraft 099sm.jpg (448.7 KB, 658 views)

Last edited by Wrenchbody; 05-26-2016 at 08:56 AM.
Wrenchbody is offline  
Old 06-01-2016, 10:14 PM
  #2  
Rabbitcreekok
Community Moderator
 
Rabbitcreekok's Avatar
 
Join Date: Aug 2005
Location: McAlester, Oklahoma
Posts: 8,065
Default

You did a really nice job on that Cub, Wrenchbody. I see that you also work on the fullsize jet versions.
Rabbitcreekok is offline  
Old 06-02-2016, 12:25 AM
  #3  
birdDog
Charging....
 
birdDog's Avatar
 
Join Date: Nov 2007
Location: Too close to Chicago.
Posts: 2,433
Default

Nicely saved from that filthy wet fuel
birdDog is offline  
Old 06-02-2016, 12:35 AM
  #4  
Porcia83
Member
 
Join Date: Feb 2010
Posts: 543
Default

Originally Posted by birdDog View Post
Nicely saved from that filthy wet fuel
lol...+1. Love the cover job, looks great.
Porcia83 is offline  
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
IsmaelPR1
Sport Planes (Formerly I/C & Gas Conversion)
2
06-03-2014 09:42 PM
Newman12
Scale E-Powered Aircraft
2
07-25-2012 04:06 AM
swapdaddyxx1
Scratch and Kit Built Aircraft
1
06-26-2012 05:50 AM
tarheal63
Scale E-Powered Aircraft
2
05-11-2012 01:30 AM
All American
Airplanes - Electric For Sale & WTB
2
02-08-2010 09:17 PM

Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off


Quick Reply: Electrified Goldberg Cub


Contact Us Archive Advertising Cookie Policy Privacy Statement Terms of Service

Copyright 2018 MH Sub I, LLC dba Internet Brands. All rights reserved. Use of this site indicates your consent to the Terms of Use.

Page generated in 0.05966 seconds with 21 queries